中文
Earlier issues
Announcement
More
Progress in Chemistry 2018, Vol. 30 Issue (2/3): 304-313 DOI: 10.7536/PC170903 Previous Articles   Next Articles

• Review •

Solvent Effects on Reaction-Controlled Phase-Transfer Catalysis

Jinshuai Zhang1, Fengli Yu1*, Bing Yuan1, Congxia Xie1*, Shitao Yu2   

  1. 1. State Key Laboratory Base of Eco-Chemical Engineering, Qingdao University of Science and Technology, Qingdao 266042;
    2. College of Chemical Engineering, Qingdao University of Science and Technology, Qingdao 266042, China
  • Received: Revised: Online: Published:
  • Supported by:
    The work was supported by the National Natural Science Foundation of China(No.21476120).
PDF ( 1598 ) Cited
Export

EndNote

Ris

BibTeX

The paper mainly discusses the effects of solvents on reaction-controlled phase-transfer catalysis which possesses the advantages of both homogeneous and heterogeneous catalysis. The reaction-controlled phase-transfer catalysis system not only realizes the catalyst recovery from the product over homogeneous catalysis but also avoids the low reaction rate, long reaction time, leaching of the active species and low selectivity in heterogeneous catalysis. For a reaction-controlled phase-transfer catalyt,its characteristic is affected not only by its composition including anion and cation but also by the used solvent during the reaction. A suitable solvent can increase the conversion rate of the substrate and the yield of product, and benefits the recovery of the catalyst. The effects of solvents on reaction-controlled phase-transfer catalysis systems including epoxidation of olefins, oxidation of alcohols to prepare aldehydes or ketones, esterification, oxidative cleavage of olefins or alcohols to prepare dicarboxylic acid, acetalation, oxidative desulfurization, hydroxylation reaction and catalytic reduction by Se, are presented in this paper. Finally, some possible measures to overcome the shortcomings in the present catalytic system are put forward and the future research prospects are discussed.
Contents
1 Introduction
2 Principle of the reaction-controlled phase-transfer catalysis
3 Effects of solvents on reaction-controlled phase-transfer catalysis
3.1 Epoxidation of olefins
3.2 Oxidation of alcohols to prepare aldehydes or ketones
3.3 Esterification
3.4 Oxidative cleavage of olefins or alcohols to prepare dicarboxylic acid
3.5 Acetalation
3.6 Oxidative desulfurization
3.7 Hydroxylation reaction
3.8 Catalytic reduction by Se
4 Conclusion and outlook
Key words: reaction-controlled phase-transfer catalysis, solvent, anionic, cationic, catalyst recovery

CLC Number: 

[1] Yang X L, Dai W L, Gao R H, Fan K N. J. Catal., 2007, 249(2):278.
[2] Zhu Q J, Chu X F, Zhang Z Y, Dai W L, Fan K N. RSC Adv., 2013, 3(6):1744.
[3] Yang X L, Qiao L M, Dai W L. Chinese J. Catal., 2015, 36(11):1875.
[4] Dioumaev V K, Bullock R M. Nature, 2003, 424(6948):530.
[5] Süβner M, Plenio H. Angew. Chem. Int. Ed., 2005, 44(42):6885.
[6] Xi Z W, Zhou N, Sun Y, Li K N. Science, 2001, 292(5519):1139.
[7] 李军(Li J), 高爽(Gao S), 奚祖威(Xi Z W). 催化学报(Chinese Journal of Catalysis), 2010, 31(08):895.
[8] 李坤兰(Li K L), 周宁(Zhou N), 奚祖威(Xi Z W). 催化学报(Chinese Journal of Catalysis), 2002, 23(02):125.
[9] Yang X G, Gao S, Xi Z W. Org. Process. Res. Dev., 2005, 9(3):294.
[10] Song Y F, Tsunashima R. Chem. Soc. Rev., 2012, 41(22):7384.
[11] Zhou Y, Guo Z J, Hou W, Wang Q, Wang J. Catal. Sci. Technol., 2015, 5(46):4324.
[12] Narkhede N, Singh S, Patel A. Green Chem., 2015, 17(1):89.
[13] Zhou Y, Chen G J, Long Z Y, Wang J. RSC. Adv., 2014, 4(79):42092.
[14] Rosnes M H, Musumeci C, Yvon C, Macdonell A, Pradeep C P, Sartorio C, Long D L, Pignataro B, Cronin L. Small, 2013, 9(13):2316.
[15] Yvon C, Surman A J, Hutin M, Alex J, Smith B O, Long D L, Cronin L, Angew. Chem., 2004, 126(13):3404.
[16] Yang H K, Su M M, Ren L J, Tang J, Yan Y K, Miao W K, Zheng P, Wang W, Eur. J. Inorg. Chem., 2013, 2013(8):1381.
[17] Misono M. Chem. Commun., 2001, 13(13):1141.
[18] Boyd T, Mitchell, S G, Miras H N, Long D L, Cronin L. Dalton Trans., 2010, 39(28):6460.
[19] Brégeault J M, Vennat M, Salles L, Piquemal J Y, Mahha Y, Briot E, Bakala P C, Atlamsani A, Thouvenot R. J. Mol. Catal. A-Chem., 2006, 250:177.
[20] Rosnes M H, Yvon C, Long D L, Cronin L. Dalton Trans., 2012, 41(33):10071.
[21] Mizuno N, Misono M. Chem. Rev., 1998, 98(1):199.
[22] Dolbecq A, Dumas E, Mayer C R, Mialane P. Chem. Rev., 2010, 110(10):6009.
[23] Fu H, Qin C, Lu Y, Zhang Z M, Li Y G, Su Z M, Li W L, Wang E B. Angew. Chem. Int. Ed., 2012, 51(32):7985.
[24] Ding Y, Zhao W, Hua H, Ma B C. Green Chem., 2008, 10(9):910.
[25] Qiao Y X, Hou Z S, Li H, Hu Y, Feng B, Wang X R, Li H, Huang Q F. Green Chem., 2009, 11(12):1955.
[26] Leng Y, Wang J, Zhu D R, Ren X Q, Ge H Q, Shen L. Angew. Chem. Int. Ed., 2009, 48(1):168.
[27] Leng Y, Jiang P P, Wang J. Catal. Commun., 2012, 25(20):41.
[28] Leng Y, Wang J, Zhu D R, Wu Y J, Zhao P P. J. Mol. Catal. A-Chem., 2009, 313(1):1.
[29] Li H, Qiao Y X, Hua L, Hou Z S, Feng B, Pan Z Y, Hu Y, Wang X R, Zhao X G, Yu Y Y. ChemCatChem, 2010, 2(9):1165.
[30] 张恒耘(Zhang H Y), 吕迎(Lv Y), 李军(Li J), 高爽(Gao S), 奚祖威(Xi Z W). 催化学报(Chinese Journal of Catalysis), 2010, 31(10):1253.
[31] Sun Y, Xi Z W, Cao G Y. J. Mol. Catal. A-Chem, 2001, 166(2):219.
[32] 杨小格(Yang X G), 张生军(Zhang S J), 李萌(Li M),奚祖威(Xi Z W), 高爽(Gao S). 催化学报(Chinese Journal of Catalysis), 2006, 27(01):50.
[33] 杨洪云(Yang H Y), 陈璐(Chen L), 高焕新(Gao H X), 金国杰(Jin G J), 丁琳(Ding L). 石油化工(Petrochemical Technology), 2008, 37(11):1172.
[34] Zhao W, Ma B C, Hua H, Zhang Y S, Ding Y. Catal. Commun., 2008, 9(14):2455.
[35] Zhao W, Ding Y. React. Kinet. Mech. Cat., 2013, 109(2):509.
[36] 李明强(Li M Q), 蹇锡高(Jian X G), 韩铁民(Han T M), 安悦(An Y). 化学学报(Acta Chemica Sinica), 2004, 62(06):540.
[37] Li H, Hou Z S, Qiao Y X, Feng B, Hu Y, Wang X R, Zhao X G. Catal. Commun., 2010, 11(5):470.
[38] Ma B C, Zhao W, Zhang F M, Zhang Y S, Wu S Y, Ding Y. RSC Adv., 2014, 4(61):32054.
[39] Zhou M D, Liu M J, Huang L L, Zhang J, Wang J Y, Li X P,Kühn F E, Zang S L. Green Chem., 2015, 17(2):1186.
[40] Zheng W G, Tan R, Yin S F, Zhao Y Y, Zhao G W, Chen Y J, Yin D H. Catal. Sci. Technol., 2015, 5(4):2092.
[41] Amarante T R, Neves P, Valente A A, Paz F A A, Pillinger M, Goncalves L S. J. Catal., 2016, 340:354.
[42] Rezaeifard A, Jafarpour M, Haddad R, Feizpour F. Catal. Commun., 2017, 95(10):88.
[43] Bortolini O, Conte V, Furia F D, Modena G. J. Org. Chem., 1986, 51(14):2661.
[44] Jing L, Shi J, Zhang F M, Zhong Y J, Zhu W D. Ind. Eng. Chem. Res., 2013, 52(30):10095.
[45] Neves P, Lysenko A B, Gomes A C, Pillinger M, Gonçalves I S, Valente A A. Catal. Lett., 2017, 147(5):1133.
[46] Guo M L. Green Chem., 2004, 6(6):271.
[47] 翁志焕(Weng Z H), 王锦艳(Wang J Y), 蹇锡高(Jian X G). 化学学报(Acta Chemica Sinica), 2008, 66(03):371.
[48] Weng Z H, Wang J Y, Jian X G. Chinese Chem. Lett., 2007, 18(8):936.
[49] 翁志焕(Weng Z H), 王锦艳(Wang J Y), 刘志勇(Liu Z Y), 蹇锡高(Jian X G). 化学学报(Acta Chemica Sinica), 2007, 65(11):1081.
[50] Weng Z H, Liao G X, Wang J Y, Jian X G. Catal. Commun., 2007, 8(10):1493.
[51] Zhang S J, Gao S, Xi Z W, Xu J. Catal. Commun., 2007, 8(3):531.
[52] Zhang S J, Zhao G D, Gao S, Xi Z W, Xu J. J. Mol. Catal. A-Chem., 2008, 289(1):22.
[53] Leng Y, Liu J, Jiang P P, Wang J. RSC Adv., 2012, 2(31):11653.
[54] Chen Y J, Tan R, Zheng W G, Zhang Y Y, Zhao G W, Yin D H. Catal. Sci. Technol., 2014, 4(11):4084.
[55] Chen G J, Zhou Y, Long Z, Wang X C, Li J, Wang J. ACS. Appl. Mater. Inter., 2014, 6(6):4438.
[56] Malakooti R, Feghhi A. New J. Chem., 2017, 41(9):3405.
[57] Fang D, Zhou X L, Ye A W, Liu Z L. Ind. Eng. Chem. Res., 2006, 45(24):7982.
[58] Binks B P, Dyab A K, Fletcher P D. Chem. Commun., 2003, 20(20):2540.
[59] Li K X, Chen L, Wang H L, Lin W B, Yan Z C. Appl. Catal. A-Gen., 2011, 392(1/2):233.
[60] Zhen B, Li H S, Jiao Q Z, Li Y, Wu Q, Zhang Y P. Ind. Eng. Chem. Res., 2012, 51(31):10374.
[61] Huang M Y, Han X X, Hung C T, Lin J C, Wu P H, Wu J C, Liu S B. J. Catal., 2014, 320(1):42.
[62] Duan X X, Sun Z, Li X Y, Wang X H, Wang S T, Li S W. Energy Technol., 2015, 3(8):871.
[63] Gao L, Liu T P, Tao X C, Huang Y M. Tetrahedron Lett., 2016, 57(44):4905.
[64] Antonelli E, D'Aloisio R, Gambaro M, Fiorani T, Venturello C. J. Org. Chem., 1999, 63(21):7190.
[65] Guo M L. Chinese J. Catal., 2003, 24(7):483.
[66] Chen H, Dai W L, Yang X L, Gao R H, Cao Y, Li H X, Fan K N. Appl. Catal. A-Gen., 2006, 309(1):62.
[67] Chen H, Dai W L, Gao R H, Cao Y, Li H X, Fan K N. Appl. Catal. A-Gen., 2007, 328(2):226.
[68] 王天华(Wang T H), 杨菲(Yang F), 于凤琴(Yu F Q), 易莎莎(Yi S S), 纪三郝(Ji S H). 山东化工(Shandong Chemical Industry), 2016, 45(2):49.
[69] Zhang J, Bao S H, Yang J G. Chinese Sci. Bull., 2009, 54(21):3958.
[70] Han X X, Yan W, Chen K, Hung C T, Liu L L, Wu P H, Huang S J, Liu S B. Appl. Catal. A-Gen., 2014, 485:149.
[71] Rafiee E, Eavani S. Catal. Commun., 2012, 25:64.
[72] 于凤丽(Yu F L), 王睿(Wang R). 化学学报(Acta Chemica Sinica), 2014, 72(1):105.
[73] Yang C B, Jin Q P, Zhang H, Liao J, Zhu J, Yu B, Deng J G. Green Chem., 2009, 11(9):1401.
[74] Nisar A, Lu Y, Zhuang J, Wang X. Angew. Chem., 2011, 123:3245.
[75] Nisar A, Zhuang J, Wang X. Adv. Mater., 2011, 23(9):1130.
[76] Zheng H W, Sun Z, Chen X L, Zhao Q, Wang X H, Jiang Z J. Appl. Catal. A-Gen, 2013, 467(10):26.
[77] Zhu W S, Wu P W, Chao Y H, Li H M, Zou F, Xun S H, Zhu F X, Zhao Z. Ind. Eng. Chem. Res., 2013, 52(49):17399.
[78] Zhuang J Z, Hu B, Tan J J, Jin X Y. Transit. Metal. Chem., 2014, 39(2):213.
[79] Yahya R, Craven M, Kozhevnikova E F, Steiner A, Samunal P, Kozhevnikov L V, Bergbreiter D E. Catal. Sci. Technol., 2015, 5(2):818.
[80] Ye J X, Wang J Y, Wang X, Zhou M D. Catal. Commun., 2016, 81:1.
[81] Mimoun H, Saussine L, Daire E, Postel M, Fischer J, Weiss R. J. Am. Chem. Soc., 1983, 105(10):3101.
[82] Nomiya K, Nemoto Y, Hasegawa T, Matsuoka S. J. Mol. Catal. A-Chem., 2000, 152(1/2):55.
[83] Zhang J, Tang Y, Li G Y, Hu C W. Appl. Catal. A-Gen., 2005, 278(2):251.
[84] Long Z Y, Zhou Y, Chen G J, Zhao P P, Wang J. Chem. Eng. J., 2014, 239:19.
[85] Li M Q, Jian X G, Han T M, Liu L, Shi Y L. Chinese J. Catal., 2004, 25(9):681.
[86] Schwendt P, Oravcová A, Tyršelová J, Paverlcik F. Polyhedron, 1996, 15(24):4507.
[87] Zhao P P, Wang J, Chen G J, Zhou Y, Huang J. Catal. Sci. Technol., 2013, 3(5):1394.
[88] Chen J Z, Ling G, Lu S W. Eur. J. Org. Chem., 2003, 34(17):3446.
[89] Chen J Z, Lu S W. Appl. Catal. A-Gen., 2004, 261(2):199.
[90] Liu X Z, Liu Q, Lu S W. Chinese J. Catal., 2004, 25(8):597.
[91] Xiang K S, Liu H, Yang B T, Zhang C, Yang S, Liu Z L, Cao L, Xie X F, Chai L Y, Min X B. Environ. Sci. Pollut. Res., 2016, 23(8):1.
[1] Zheng Chen, Zhenhua Jiang. Discussion on Some Chemical Problems of Polymer Condensed Statein Solvent-Free Polymer Production Technology [J]. Progress in Chemistry, 2022, 34(7): 1576-1589.
[2] Ru Jiang, Chenxu Liu, Ping Yang, Shuli You. Condensed Matter Chemistry in Asymmetric Catalysis and Synthesis [J]. Progress in Chemistry, 2022, 34(7): 1537-1547.
[3] Li Jintao, Zhang Mingzu, He Jinlin, Ni Peihong. Application of Deep Eutectic Solvents in Polymer Synthesis [J]. Progress in Chemistry, 2022, 34(10): 2159-2172.
[4] Guoyong Huang, Xi Dong, Jianwei Du, Xiaohua Sun, Botian Li, Haimu Ye. High-Voltage Electrolyte for Lithium-Ion Batteries [J]. Progress in Chemistry, 2021, 33(5): 855-867.
[5] Yu Yin, Chunhui Ma, Wei Li, Shouxin Liu. Solvent System and Conversion Mechanism of 5-Hydroxymethylfurfural Preparation from Glucose [J]. Progress in Chemistry, 2021, 33(10): 1856-1873.
[6] Dechao Wang, Yangyang Xin, Xiaoqian Li, Dongdong Yao, Yaping Zheng. Porous liquids and Their Applications in Gas Capture and Separation [J]. Progress in Chemistry, 2021, 33(10): 1874-1886.
[7] Lixu Lei, Yiming Zhou. Solvent-Free or Less-Solvent Solid State Reactions [J]. Progress in Chemistry, 2020, 32(8): 1158-1171.
[8] Bingqian Huang, Liyan Wang, Xuan Wei, Weichao Xu, Zhen Sun, Tinggang Li. Lignocellulose Pretreatment by Deep Eutectic Solvents for Biobutanol production [J]. Progress in Chemistry, 2020, 32(12): 2034-2048.
[9] Jingshi Liang, Jiaming Zeng, Junjie Li, Jueqin She, Ruixuan Tan, Bo Liu. Cationic Antimicrobial Polymers [J]. Progress in Chemistry, 2019, 31(9): 1263-1282.
[10] Hao Zhang, Jing Liu, Kun Cui, Tao Jiang, Zhi Ma. Synthesis and Application of Guanidine-Based Antibacterial Polymers [J]. Progress in Chemistry, 2019, 31(5): 681-689.
[11] Jianxi Zhao, Panpan Gu, Hui Zeng, Shenglu Deng. Self-Assembly of Surfactants in Non-Polar Organic Solvents [J]. Progress in Chemistry, 2019, 31(5): 643-653.
[12] Wanru Zhao, Xin Hu, Ning Zhu, Zheng Fang, Kai Guo. Ionic Polymerizations in Continuous Flow [J]. Progress in Chemistry, 2018, 30(9): 1330-1340.
[13] Yunchao Feng, Miao Zuo, Xianhai Zeng*, Yong Sun, Xing Tang, Lu Lin*. Preparation of 5-Hydroxymethylfurfural from Glucose [J]. Progress in Chemistry, 2018, 30(2/3): 314-324.
[14] Dongya Bai, Junyao He, Bin Ouyang, Jin Huang, Pu Wang. Biocatalytic Asymmetric Synthesis of Chiral Aryl Alcohols [J]. Progress in Chemistry, 2017, 29(5): 491-501.
[15] Sun Jia, Wang Pu, Zhang Pengpeng, Huang Jin. Application of Glycerol in Microbial Biosynthesis and Biocatalysis [J]. Progress in Chemistry, 2016, 28(9): 1426-1434.